|
| Author |
Message |
    
SteveFredrick
Visitor
| | Posted on Sunday, December 30, 2007 - 10:01 am: | 
|
I have a 1986 4-108, 2700 hours. Engine has been running fine with no smoke, then the injection pump started leaking, so I had it rebuilt, then reinstalled with timing marks aligned. Heavy black smoke started at wide open throttle, full load. Had the injectors rebuilt, new lift pump, new exhaust elbow, muffler, hose, etc. Pump rebuilder has suggested advancing timing slightly. Any suggestions? I am baffled as it was running perfectly before all the fuel system repairs. |
rodney breustedt
Member
Username: rodneyb
Post Number: 4
Registered: 12-2007
| | Posted on Sunday, December 30, 2007 - 10:30 am: |
|
again i would go back to basics, perhaps engine is just tired and now with new pump system operating at max you just cant burn properly all the fuel being injected into cylinders, this isnt the first time ive heard these concerns after rebuilding injector systems, have you engine tested compression/leak down and procede
from there, good luck . rodney. |
SteveFredrick
Visitor
| | Posted on Sunday, December 30, 2007 - 03:44 pm: |
|
Hi Rodney
I did not check compression as the engine was running perfectly before the rebuild. I cannot attain the same RPM's or the same boat speed under load as before the rebuild. At no load, I can reach max revs. The engine starts instantly just as before.
I will post an eventual resolution to this issue, but it may take a while. |
Ken Bloomfield
Visitor
| | Posted on Thursday, March 27, 2008 - 09:28 am: |
|
Remember that the fuel amount delivered for a given RPM is adjusted by the governor setting. I suspect that for some reason, that for a given RPM the injector pump is delivering too much fuel. Tends to be aggravated at the high RPM end due to loading. I would have the pump given a re-look over. |
new holland
Visitor
| | Posted on Sunday, April 27, 2008 - 05:13 pm: |
|
I have a mid 80s new holland skid steer l555 with a perkins diesel it smokes a lot at start up. The smoke dosnt go away when fully warm its not as bad but it still smokes. Its kinda whitesh or blueish in color.Do you think it could be the fuel injectors? Other than that it runs good has a lot of power. I changed the air filter and it seam to help a little it doesnt smoke as bad. when it sits over night it takes a little time to get it started on warm days or cold. THANKS |
|
|
|
Product Categories |
| Engine Parts · By Brand |
| Engine Manuals · By Brand |
| Books |
| General Repair and Maint. |
| Care and Repair |
| · Adhesive and Sealants |
| · Bottom Cleaners |
| · Cleaners Wax and Polish |
| · Mops Brushes and Sponges |
| Covers and Tops |
| · Bimini Tops · Hardware |
| · Cover Accessories |
| · Motor Covers |
| · Universal Boat Covers |
| Electronics |
| · Gauges and Compasses |
| · Mounts and Accessories |
| Electrical |
| · Batteries & Chargers |
| · Battery Accessories |
| · Dockside Electrical |
| · Electrical Terminals |
| · Electrical Wire, Cable |
| · Fuses, Fuse Holders |
| · Switches |
| · Wire Ties, Clips, Tape |
| Fuel Systems |
| · Fuel Tanks |
| · Fittings, Fills, Vents |
| · Hose & Primer Bulbs |
| · Filters, Senders, Caps |
| Hardware |
| · Deck Cabin Hardware |
| · Molding and Rub Rails |
| · Rails and Fittings |
| · Snaps Shackles and Hooks |
| · Windshield Hardware |
| Lighting |
| · Cabin Lights · Light Bulbs |
| · Navigation Light Parts |
| · Navigation Lights |
| · Spotlights · Parts |
| Mooring and Dock |
| · Boat Fenders · Boat Hooks |
| · Buoys and Markers |
| · Deck Cleats · Dock Edging |
| · Dock Parts and De-Icers |
| · Fender Covers and Holders |
| · Keelshield / Toon-Tectors |
| · Ladders and Platforms |
| Prop / Trim /
Transom |
| · Jack Plates, Wedges |
| · Mounting Brackets |
| · Outboard Stands |
| · Trim Tabs, Stablizers |
| · Prop Nuts, Locks, Pins |
| · Propellers · Wrenches |
| Pumps |
| · Aerator Pumps |
| · Bilge Pumps |
| · Drain Plugs and Tubes |
| · Hose · Through Hull Fittings |
| Rope and Cordage |
| · Anchor Line · Dock Line |
| · Fender Line · Bulk Rope |
| · Shock Cord and Bungee |
| Safety Products |
| · Horns Bells and Whistles |
| · Mirrors |
| · Vents Blowers and Hose |
| Sanitation |
| · Fresh Water Pumps |
| · Marine Toilets |
| · Sanitation Chemicals |
| · Sanitation Pumps/Hose |
| · Water/Waste System Parts |
| Seating |
| · Deck Chairs and Tables |
| · Fishing Seats |
| · Lounge Seats |
| · Pontoon Furniture |
| · Seat Bases and Pedestals |
| Steering / Control |
| · Control
Boxes |
| · Control
Cables |
| · Hydraulic
Steering |
| · Mechanical
Steering |
| · Rigging · Steering
Wheels |
| Tools / Shop Supplies |
| · Lubricants & Additives |
| · Motor Flushers |
| · Tools & Test Equipment |
| Trailering |
| · Boat Guides/Motor Support |
| · Hitches Balls Couplers |
| · Rollers Brackets Springs |
| · Tires Wheels and Carriers |
| · Trailer Hubs & Bearings |
| · Trailer Jacks |
| · Trailer Wiring and Lighting |
| · Winches Straps Tie Downs |
| Manufacturer List |
|
