|
| 2004 DF 115 runs 3000 r/m at idle |
| Author |
Message |
    
Rob O
New member
Username: roboat
Post Number: 1
Registered: 05-2008
| | Posted on Friday, May 09, 2008 - 07:15 pm: | 
|
Need some advise, engine gave beep every 8 sec.
Starts normal and when in gear, beep was gone.
Suddenly, when started engine runs 3000 r/m.
Reset makes no difference, only 3000 r/m is the result.
Chequed cables in motor, everything looks normal.
Suzuki dealers dont have a clue. |
JUST-IN-TIME
Senior Member
Username: justintime
Post Number: 4087
Registered: 09-2006
| | Posted on Saturday, May 10, 2008 - 11:36 am: |
|
water in fuel |
Rob O
New member
Username: roboat
Post Number: 2
Registered: 05-2008
| | Posted on Saturday, May 10, 2008 - 10:48 pm: |
|
Hi JustinTime, thanks for reply,i'm going to install a water-fuelseparator.
But (as a nono) i still cant explain why it runs 3000, and a Suzuki doesn't run on water??
With all the sensors and other complex stuff the engine has failed for the fifth time (now i was flowting helpless in the route of a cruiseship sailing out) Btw how can you get water out of the system? Or is a littlebit enough to drive the Suzuki nuts? With regards Robo
ps. the dealers only want to look at my problem with the laptop (and none has the time for the first 3 weeks) |
JUST-IN-TIME
Senior Member
Username: justintime
Post Number: 4117
Registered: 09-2006
| | Posted on Wednesday, May 14, 2008 - 12:38 am: |
|
so it stays only at 3000 |
Rob O
New member
Username: roboat
Post Number: 3
Registered: 05-2008
| | Posted on Wednesday, May 14, 2008 - 07:26 am: |
|
Yes, when i turn on the key....the engine immediatily runs at fixed 3000rpm.
So you can"t put it in gear (without damaging the engine or without being blown out of the boat) |
JUST-IN-TIME
Senior Member
Username: justintime
Post Number: 4127
Registered: 09-2006
| | Posted on Wednesday, May 14, 2008 - 10:19 pm: |
|
sounds like you need to adjust iac
but disconnect the throttle cable |
|
|
|
Product Categories |
| Engine Parts · By Brand |
| Engine Manuals · By Brand |
| Books |
| General Repair and Maint. |
| Care and Repair |
| · Adhesive and Sealants |
| · Bottom Cleaners |
| · Cleaners Wax and Polish |
| · Mops Brushes and Sponges |
| Covers and Tops |
| · Bimini Tops · Hardware |
| · Cover Accessories |
| · Motor Covers |
| · Universal Boat Covers |
| Electronics |
| · Gauges and Compasses |
| · Mounts and Accessories |
| Electrical |
| · Batteries & Chargers |
| · Battery Accessories |
| · Dockside Electrical |
| · Electrical Terminals |
| · Electrical Wire, Cable |
| · Fuses, Fuse Holders |
| · Switches |
| · Wire Ties, Clips, Tape |
| Fuel Systems |
| · Fuel Tanks |
| · Fittings, Fills, Vents |
| · Hose & Primer Bulbs |
| · Filters, Senders, Caps |
| Hardware |
| · Deck Cabin Hardware |
| · Molding and Rub Rails |
| · Rails and Fittings |
| · Snaps Shackles and Hooks |
| · Windshield Hardware |
| Lighting |
| · Cabin Lights · Light Bulbs |
| · Navigation Light Parts |
| · Navigation Lights |
| · Spotlights · Parts |
| Mooring and Dock |
| · Boat Fenders · Boat Hooks |
| · Buoys and Markers |
| · Deck Cleats · Dock Edging |
| · Dock Parts and De-Icers |
| · Fender Covers and Holders |
| · Keelshield / Toon-Tectors |
| · Ladders and Platforms |
| Prop / Trim /
Transom |
| · Jack Plates, Wedges |
| · Mounting Brackets |
| · Outboard Stands |
| · Trim Tabs, Stablizers |
| · Prop Nuts, Locks, Pins |
| · Propellers · Wrenches |
| Pumps |
| · Aerator Pumps |
| · Bilge Pumps |
| · Drain Plugs and Tubes |
| · Hose · Through Hull Fittings |
| Rope and Cordage |
| · Anchor Line · Dock Line |
| · Fender Line · Bulk Rope |
| · Shock Cord and Bungee |
| Safety Products |
| · Horns Bells and Whistles |
| · Mirrors |
| · Vents Blowers and Hose |
| Sanitation |
| · Fresh Water Pumps |
| · Marine Toilets |
| · Sanitation Chemicals |
| · Sanitation Pumps/Hose |
| · Water/Waste System Parts |
| Seating |
| · Deck Chairs and Tables |
| · Fishing Seats |
| · Lounge Seats |
| · Pontoon Furniture |
| · Seat Bases and Pedestals |
| Steering / Control |
| · Control
Boxes |
| · Control
Cables |
| · Hydraulic
Steering |
| · Mechanical
Steering |
| · Rigging · Steering
Wheels |
| Tools / Shop Supplies |
| · Lubricants & Additives |
| · Motor Flushers |
| · Tools & Test Equipment |
| Trailering |
| · Boat Guides/Motor Support |
| · Hitches Balls Couplers |
| · Rollers Brackets Springs |
| · Tires Wheels and Carriers |
| · Trailer Hubs & Bearings |
| · Trailer Jacks |
| · Trailer Wiring and Lighting |
| · Winches Straps Tie Downs |
| Manufacturer List |
|
