|
| Author |
Message |
    
Joe Cascanette
New member
Username: joe_c
Post Number: 1
Registered: 04-2008
| | Posted on Friday, April 25, 2008 - 07:37 am: | 
|
I am just waiting to receive my shop manual, but thought i would post this anyways.
I tried to search for an answer with no luck.
motor: 99 yammy 90hp
issue: adjusting the shift cable (or i hope i have the term right)
See link to picture at bottom of the page
Where i need some guideance is where the pivot is enguaging the carb contol arm. At that point there is a plastic part (in a shape of a trangle) that when you enguage the motor will pivot and open/close the carbs. There is a roller that glides along this plastic part and in its current state is sitting on the other side of this parts shoulder. So when I put the engine into drive the roller has to roll over the shoulder first (causing a stiff shift). After it rolls over this part the control of the engine speed is fine.
In the current setup my idle is around 800-900rpm.
If i adjust the shift rod (that enguages the carbs) to the correct position (just on the edge of the shoulder, where i think it should be) the idle RPM is around 1200, and the idle adjust screw is not touching anywhere.
So here is what i am looking for. The part name is one and is there a way to adjust the carbs after i put the adjusting arm in the correct position, or what is the correct position?
http://www.flickr.com/photos/cascanette/2440070003/ |
JUST-IN-TIME
Senior Member
Username: justintime
Post Number: 3879
Registered: 09-2006
| | Posted on Friday, April 25, 2008 - 06:46 pm: |
|
wait to the manual
do not mess with it |
|
|
|
Product Categories |
| Engine Parts · By Brand |
| Engine Manuals · By Brand |
| Books |
| General Repair and Maint. |
| Care and Repair |
| · Adhesive and Sealants |
| · Bottom Cleaners |
| · Cleaners Wax and Polish |
| · Mops Brushes and Sponges |
| Covers and Tops |
| · Bimini Tops · Hardware |
| · Cover Accessories |
| · Motor Covers |
| · Universal Boat Covers |
| Electronics |
| · Gauges and Compasses |
| · Mounts and Accessories |
| Electrical |
| · Batteries & Chargers |
| · Battery Accessories |
| · Dockside Electrical |
| · Electrical Terminals |
| · Electrical Wire, Cable |
| · Fuses, Fuse Holders |
| · Switches |
| · Wire Ties, Clips, Tape |
| Fuel Systems |
| · Fuel Tanks |
| · Fittings, Fills, Vents |
| · Hose & Primer Bulbs |
| · Filters, Senders, Caps |
| Hardware |
| · Deck Cabin Hardware |
| · Molding and Rub Rails |
| · Rails and Fittings |
| · Snaps Shackles and Hooks |
| · Windshield Hardware |
| Lighting |
| · Cabin Lights · Light Bulbs |
| · Navigation Light Parts |
| · Navigation Lights |
| · Spotlights · Parts |
| Mooring and Dock |
| · Boat Fenders · Boat Hooks |
| · Buoys and Markers |
| · Deck Cleats · Dock Edging |
| · Dock Parts and De-Icers |
| · Fender Covers and Holders |
| · Keelshield / Toon-Tectors |
| · Ladders and Platforms |
| Prop / Trim /
Transom |
| · Jack Plates, Wedges |
| · Mounting Brackets |
| · Outboard Stands |
| · Trim Tabs, Stablizers |
| · Prop Nuts, Locks, Pins |
| · Propellers · Wrenches |
| Pumps |
| · Aerator Pumps |
| · Bilge Pumps |
| · Drain Plugs and Tubes |
| · Hose · Through Hull Fittings |
| Rope and Cordage |
| · Anchor Line · Dock Line |
| · Fender Line · Bulk Rope |
| · Shock Cord and Bungee |
| Safety Products |
| · Horns Bells and Whistles |
| · Mirrors |
| · Vents Blowers and Hose |
| Sanitation |
| · Fresh Water Pumps |
| · Marine Toilets |
| · Sanitation Chemicals |
| · Sanitation Pumps/Hose |
| · Water/Waste System Parts |
| Seating |
| · Deck Chairs and Tables |
| · Fishing Seats |
| · Lounge Seats |
| · Pontoon Furniture |
| · Seat Bases and Pedestals |
| Steering / Control |
| · Control
Boxes |
| · Control
Cables |
| · Hydraulic
Steering |
| · Mechanical
Steering |
| · Rigging · Steering
Wheels |
| Tools / Shop Supplies |
| · Lubricants & Additives |
| · Motor Flushers |
| · Tools & Test Equipment |
| Trailering |
| · Boat Guides/Motor Support |
| · Hitches Balls Couplers |
| · Rollers Brackets Springs |
| · Tires Wheels and Carriers |
| · Trailer Hubs & Bearings |
| · Trailer Jacks |
| · Trailer Wiring and Lighting |
| · Winches Straps Tie Downs |
| Manufacturer List |
|
