|
| Author |
Message |
    
bob borton
Member
Username: bbort72
Post Number: 4
Registered: 06-2007
| | Posted on Sunday, May 18, 2008 - 08:55 pm: | 
|
Hi, the issue I am having with my motor is the warning horn sounds all the time when I start the motor. I had the water pump impeller replaced thinking that might be the problem but it still continues to sound. I checked the fuel filter, no problems there. Once in a while when I start the motor it does not alarm. The motor runs great and is not overheating,just makes that ungodly warning sound. One day I hit the throttle lever on top on the shifter control and it stopped. Is there a wire inside of the control case that could be loose? If so how hard is it to take it apart to cheheck it? Right now to make it quit I turn the key half way off until it stops but then that also shuts down the rest of my gauges. |
A Waterman
Visitor
| | Posted on Sunday, May 18, 2008 - 11:47 pm: |
|
its not uncommon for horns to short out open up the box check wires or replace horn its a fairly easy job just keep track of where parts go theres not many loose ones involed just to change a horn |
jwbmarine
Senior Member
Username: jwbmarine
Post Number: 1564
Registered: 11-2005
| | Posted on Monday, May 19, 2008 - 09:25 am: |
|
are u still using the VRO oiling system?..
another item,would be to disc the tan wire leading from cycl hd on eng,and see if horn quits.u prob,have a bad horn. |
bob borton
Member
Username: bbort72
Post Number: 5
Registered: 06-2007
| | Posted on Monday, May 19, 2008 - 11:57 am: |
|
Yes, i am still using the VRO system, I will try to disconnect the tan wire. If the horn quits when I disconnect the wire what would that indicate? |
jwbmarine
Senior Member
Username: jwbmarine
Post Number: 1573
Registered: 11-2005
| | Posted on Monday, May 19, 2008 - 12:07 pm: |
|
bad sender in hd,..
disc wires going to oil tank...to see if sender is bad there.
disc wires going to vro to see if bad elect there...dont forget-- to reconnect after test...process of elimination,...if all senders are disc at eng,..u would need to go into control box,or where your horn is,....to make sure nothing is grounding it,causing it to activate. |
|
|
|
Product Categories |
| Engine Parts · By Brand |
| Engine Manuals · By Brand |
| Books |
| General Repair and Maint. |
| Care and Repair |
| · Adhesive and Sealants |
| · Bottom Cleaners |
| · Cleaners Wax and Polish |
| · Mops Brushes and Sponges |
| Covers and Tops |
| · Bimini Tops · Hardware |
| · Cover Accessories |
| · Motor Covers |
| · Universal Boat Covers |
| Electronics |
| · Gauges and Compasses |
| · Mounts and Accessories |
| Electrical |
| · Batteries & Chargers |
| · Battery Accessories |
| · Dockside Electrical |
| · Electrical Terminals |
| · Electrical Wire, Cable |
| · Fuses, Fuse Holders |
| · Switches |
| · Wire Ties, Clips, Tape |
| Fuel Systems |
| · Fuel Tanks |
| · Fittings, Fills, Vents |
| · Hose & Primer Bulbs |
| · Filters, Senders, Caps |
| Hardware |
| · Deck Cabin Hardware |
| · Molding and Rub Rails |
| · Rails and Fittings |
| · Snaps Shackles and Hooks |
| · Windshield Hardware |
| Lighting |
| · Cabin Lights · Light Bulbs |
| · Navigation Light Parts |
| · Navigation Lights |
| · Spotlights · Parts |
| Mooring and Dock |
| · Boat Fenders · Boat Hooks |
| · Buoys and Markers |
| · Deck Cleats · Dock Edging |
| · Dock Parts and De-Icers |
| · Fender Covers and Holders |
| · Keelshield / Toon-Tectors |
| · Ladders and Platforms |
| Prop / Trim /
Transom |
| · Jack Plates, Wedges |
| · Mounting Brackets |
| · Outboard Stands |
| · Trim Tabs, Stablizers |
| · Prop Nuts, Locks, Pins |
| · Propellers · Wrenches |
| Pumps |
| · Aerator Pumps |
| · Bilge Pumps |
| · Drain Plugs and Tubes |
| · Hose · Through Hull Fittings |
| Rope and Cordage |
| · Anchor Line · Dock Line |
| · Fender Line · Bulk Rope |
| · Shock Cord and Bungee |
| Safety Products |
| · Horns Bells and Whistles |
| · Mirrors |
| · Vents Blowers and Hose |
| Sanitation |
| · Fresh Water Pumps |
| · Marine Toilets |
| · Sanitation Chemicals |
| · Sanitation Pumps/Hose |
| · Water/Waste System Parts |
| Seating |
| · Deck Chairs and Tables |
| · Fishing Seats |
| · Lounge Seats |
| · Pontoon Furniture |
| · Seat Bases and Pedestals |
| Steering / Control |
| · Control
Boxes |
| · Control
Cables |
| · Hydraulic
Steering |
| · Mechanical
Steering |
| · Rigging · Steering
Wheels |
| Tools / Shop Supplies |
| · Lubricants & Additives |
| · Motor Flushers |
| · Tools & Test Equipment |
| Trailering |
| · Boat Guides/Motor Support |
| · Hitches Balls Couplers |
| · Rollers Brackets Springs |
| · Tires Wheels and Carriers |
| · Trailer Hubs & Bearings |
| · Trailer Jacks |
| · Trailer Wiring and Lighting |
| · Winches Straps Tie Downs |
| Manufacturer List |
|
