Logo
Results 1 to 2 of 2
  1. #1

    Default NEW Trim sender problemt

    1988 Regal Sebring 4.3 Alpha One, gen 1. - I installed a new set of trim limit & sender by Kemimoto. The gimble houseing bellows and hose are all in and buttoned up. When it came time to adjust the limit, no problem. Before attaching the sender I wanted to check the dash dial so I turned the hinge pin gear slowly to see if the dial responded. It did. When I fastened the sender to the lower unit and tested the dial again. The dial showed correct movement the first time or two, but then the dial would not move from full down. I took the unit apart and found one of the contacts to be bent. I carefully put it back in place but seemed like it might break. I then took the boat for a test drive. The dial read correctly for a trim up and down a couple times but then the gage dial went to full up (in the red). Apparently the contact did fail. I am not planning to replace the sender unit as it requires disassembling the entire gimble housing. I think that some kind of repair could be implemented without removing the wire. If I got another sender puck, could I remove the wire connect inside the puck and connect a new one. What about splicing the wires?

  2. #2
    Join Date
    Sep 2010
    Location
    Jersey Shore
    Posts
    4,567

    Default Re: NEW Trim sender problemt

    You can change the sender with out taking the drive off. You need a 11mm or 7/16m 1/4" drive swivel socket and a long extension. and some patience.

    Replace your senders with Quick Silver parts.
    Chris
    Dockside Marine Services
    Jersey Shore.
    Mercruiser/Mercury Certified
    Let the insanity begin.

Similar Threads

  1. Bravo 3 Outdrive - Trim Sender & Limit Switch / Power Trim Tilt Relays
    By self-maintained-boater in forum Mercruiser Sterndrive Forum
    Replies: 14
    Last Post: 08-01-2017, 10:51 AM
  2. Trim Sender/Trim Gauge Question
    By Johnathan Steil in forum Boat Electrical Systems
    Replies: 2
    Last Post: 05-12-2016, 11:39 AM
  3. 225 opti trim sender & tach sender
    By 9 shots in forum Mercury Mariner Outboard Forum
    Replies: 1
    Last Post: 10-01-2013, 07:47 PM
  4. Trim sender
    By donmega in forum Mercruiser Sterndrive Archive
    Replies: 1
    Last Post: 08-22-2007, 01:48 AM
  5. Trim Sender
    By jerryh in forum Mercruiser Sterndrive Archive
    Replies: 2
    Last Post: 08-22-2007, 01:44 AM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •