Logo
Click for Bukh manuals!
Results 1 to 5 of 5
  1. #1
    edward bleakley's Avatar
    edward bleakley Guest

    Default "Elevated oil level and almost

    "Elevated oil level and almost white. expected it to be through the water pump or the head gasket, but after a new pump and a look at the gasket is neither. Suspect piston jackets? any thoughts or replacement/fix ideas greatly appreciated."

  2. #2

    Default "If you do not shut off throug

    "If you do not shut off through hull sea water intake after engine shutdown, I believe water can siphon back through the exhaust after shutdown if the exhaust elbow is below waterline and there is no siphon break loop in the discharge line from thermostat to exhaust elbow. Bukh has an instruction sheet on this with their exhaust parts. Good Luck."

  3. #3

    Default Its a common problem the drive

    Its a common problem the drive gear bearing for the water pump will have collapsed remove cover and all will become obvious

  4. #4
    Stan D.'s Avatar
    Stan D. Guest

    Default "Milmar, It sounds like the s

    "Milmar, It sounds like the same kind of problem in my friend's dv-20. Only, the manual shows bushings instead of bearings. Do you know if this is the same? How would water get past the pump seals around the shaft? Would worn bushings allow water to get past the seals?

    Thanks"

  5. #5

    Default Re: DV 24 ME seawater in oil

    The seal wears out and some after market seals do not have Bukhs Bronze retain spring for the lip instead they have a stainless steel spring Bushing should be fine
    Just realized this threads for a Bukh DV24 the water pump I believe should have bearing not bushing which Bukh used on there older DV20 as Ive only just joined here I can up load photos sorry
    Last edited by HG02; 08-22-2015 at 11:42 PM.

Similar Threads

  1. AQ131a Seawater Leak
    By brian_zim in forum Volvo Penta Gas Engine Forum
    Replies: 4
    Last Post: 08-30-2010, 12:36 AM
  2. Draining Seawater System
    By mitch2008 in forum Mercruiser Sterndrive Archive
    Replies: 3
    Last Post: 07-28-2009, 01:12 PM
  3. 2002 Freshwater or Seawater
    By dsiegfried in forum Volvo Penta Diesel Archive 2004-2009
    Replies: 2
    Last Post: 05-13-2008, 07:46 AM
  4. Freshwater to seawater
    By hbbutler in forum Mercruiser Sterndrive Archive
    Replies: 6
    Last Post: 09-01-2007, 10:23 PM
  5. Seawater Pump
    By Steve Willis in forum Mercruiser Sterndrive Archive
    Replies: 4
    Last Post: 08-24-2007, 08:01 AM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •